Tesla model S Dual-Motor is quicker, has higher range - WBRC FOX6 News - Birmingham, AL

Tesla model S Dual-Motor is quicker, has higher range

© iStockphoto.com © iStockphoto.com
By David Noland


How can you add all-wheel drive to an electric car, making it hundreds of pounds heavier--and still increase its efficiency and range?

Amid all of last week's hoopla over the blazing performance of the all-wheel-drive Tesla Model S P85D--0 to 60 mph in 3.2 seconds, 155-mph top speed--what really caught my eye was this: Tesla accomplished it all while actually improving the efficiency of the car, despite a weight gain of almost 300 pounds.

That's unheard of.

Every car powered by an internal-combustion engine loses efficiency when all-wheel drive is added. It's due to friction losses in the extra shafts and gears,  as well as the additional weight.

A rear-wheel-drive BMW 328i, for example, drops from 27 mpg combined to 26 if you add the X-drive all-wheel-drive system.

Standard 85D: even more efficient

In the standard 85-kWh Model S that most buyers will likely choose, Tesla's new AWD system boosts the range by anywhere from 4 to 19 percent--depending on which of Tesla's contradictory numbers you believe.

The official EPA combined range of the standard S-85 is 265 miles. On its website configurator, Tesla says the new AWD version will go 295 miles at  65 mph.  (Temperature and climate-control use are not specified.)

Though it's not quite an apples-to-apples comparison, that's an 11-percent improvement.

The range calculator on the Tesla website provides another basis for comparison. At a steady 65 mph, at 70 degrees with climate control on, the range calculator says the standard  S-85 will go 242 miles. 

By that yardstick, the range bonus for the 85D is even more astounding: 53 miles, or 19 percent.

On the other hand, a blog post on the Tesla website says that both the 85D and 60D pick up an additional 10 miles of range over their single-motor counterparts. 

That number is suspect on the face of it, however: With its smaller battery and shorter range, the 60D should have a proportionally smaller advantage over the standard 60-kWh model.

The most accurate comparison, however, may be that suggested by a speed vs range curve published in a 2012 blog post by Elon Musk and Tesla CTO JB Straubel on the Tesla website.  

That curve shows the 85-kWh Model S to have a range of 262 miles at a steady 65 mph, the same condition ascribed to the 85D's 295-mile range. That's an increase of 33 miles, or 13 percent.

Take your pick: 30 miles of extra range, or 33 miles, or 53 miles...or 10 miles.

Whichever is correct, that's an impressive engineering feat.

Different AWD systems

As it turns out, the AWD system on the standard Model S 85D is markedly different from that of the much-ballyhooed P85D.

On the P85D, Tesla pretty much maintained the existing high-performance rear motor--at 350 kilowatts (470 horsepower)--and added an additional 165-kW (221-hp) motor up front.

The result is a 47-percent increase in total power, to a mind-boggling 515 kW (691 hp). No surprise that performance went off the charts. It's a simple matter of power-to-weight ratio.

But something different is going on with the AWD version of the standard 85-kWh and 60-kWh versions of the Model S when D all-wheel drive is added.

The 85D and 60D replace the previously standard 285-kW (380-hp) rear motor with a pair of 140-kW (188-hp) motors, one front and one rear. That gives a total of 280 kW (376 hp), which is actually a slight decrease in total horsepower.

No details have been released yet about the new, less powerful motor fitted to those vehicles.

Is it merely a derated version of the current 285-kW motor, or something all new?  A version of the 115-kW (154-hp) motor that Tesla provided to Toyota for the RAV4 EV? Or the 132-kW (177-hp) one provided to Mercedes for its B Class Electric Drive?

Despite the slight power cut, 0-to-60-mph time for the 85D falls from 5.4 to 5.2 seconds. Top speed rockets from 125 mph to 155 mph. And, of course, it's 4 to 19 percent more efficient.

So...how the heck did they do that?

Two-motor versatility

During the D reveal, Tesla Motors CEO Elon Musk gave a general idea of how this was accomplished.

"Because we have two drive units, where we can shift the power from front to rear, and constantly be at the optimal efficiency point for each motor," Musk said, "we're actually able to overcome the penalty of the increased mass of the motor."

Later he elaborated  for Bloomberg News: "We're able to balance the efficiency of the motors....If you have just one motor, it's always on a particular power-vs-efficiency curve."

"But if you have two motors, you can optimize between them, and have the motors operate in their more efficient regime more of the time."

While Musk didn't get further into the details of this system,  it's likely that one motor is optimized for powerful acceleration,  the other for efficient high-speed cruising.

Presumably each has a gear ratio optimized for its primary duty. Power is then shunted to whichever motor is in the more efficient part of its power/efficiency curve and rpm range for the job at hand.

Single-motor compromise

Due to the rotating-speed limits of a single fixed-gear motor, Tesla designers originally had to choose between acceleration and top speed for the standard single-motor Model S.

They clearly chose acceleration, at the expense of top speed.

The single-motor 85-kWh Model S has a top speed of 125 mph--far slower than comparable sport sedans with similar power.

It's a flaw that's largely irrelevant to most U.S. buyers, but it has apparently hurt Model S sales in Germany, where the ability to cruise at 130 to 140 mph on the Autobahns is de rigueur in a car costing $100,000 or more.

The new 85D , with two motors, has the best of both worlds.

We would presume the rear motor is geared low for quick acceleration, while the front motor pushes a taller "overdrive" gear for more efficient high-speed cruising.

The fact that top speed has jumped from 125 to 155 without a power increase suggests a radical change in gearing for at least one of the motors.

All in all, improving acceleration, top speed, and efficiency in a heavier car is an engineering tour de force that Tesla should be very proud of.

And it's one more example of the inherent superiority of the electric motor over combustion engines when it comes to the business of propelling a car.

We can picture engineers at BMW, Mercedes, and Audi pounding their heads on their desks in frustration.

You almost have to feel sorry for the poor guys still stuck working on those old-fashioned cars with combustion engines.


This story originally appeared at Green Car Reports

© 2014 GreenCarReports.com
All rights reserved.
*DISCLAIMER*: The information contained in or provided through this site section is intended for general consumer understanding and education only and is not intended to be and is not a substitute for professional advice. Use of this site section and any information contained on or provided through this site section is at your own risk and any information contained on or provided through this site section is provided on an "as is" basis without any representations or warranties.
Powered by Frankly